American Oil and Gas Reporter - September 2015 - 119

the nominal operating pressure of 200
psi to 380 psi as compressor stations fail
or go down," Easley relates. "It also has
seen temperatures ranging from -30 to
180 degrees Fahrenheit. After two years,
we have had no problems."
Easley attributes the pipe's success to
its toughness. "The nylon pipe has four
times the abrasion resistance of high-density
polyethylene, a common material in composite pipes, and two times the abrasion
resistance of steel," he reports. "That means
the outside is less likely to be damaged
when it is dragged across the ground during
installation, and the inside is less likely to
wear if the pipe transports sand-laden fluid
or other abrasive materials."
The pipe offers six times the impact
resistance of HDPE, Easley adds. "If the
pipe is where vehicles might run over it,
cows might step on it, or tools might
strike it, the improved impact resistance
can extend pipe life considerably," he
says.
To simplify installation, Easley says
the most popular pipe diameters are coiled
in continuous strands as long as 1,000
feet. "The strands are connected using
standard butt-fusion equipment," he notes.
"It is the same equipment used for HDPE,
so it is readily available, and there are a
lot of experienced crews that can learn

Raptor™ nylon pipe from INVISTA combines low installation and maintenance costs with
the durability to withstand temperature and pressure fluctuations, INVISTA reports.

how to install the pipe in only a few
hours."
Once installed, the pipe has low maintenance costs, Easley adds. "It resists
corrosion naturally, so the operator does
not need to install or maintain a cathodic
protection system," he points out.
"Because it has lower thermal conductivity than steel and HDPE, paraffin
is less likely to build up," he continues.
"Also, the surface is smoother than steel,
which further reduces paraffin buildup,
resulting in less need for cleaning."
Moreover, Easley says the pipe's installed cost averages 30-60 percent that
of steel. "The cost savings compared

with other spoolable composites vary
widely, but we might save 30 percent,"
he remarks.
Although the pipe generally has a
long-term pressure rating of 350-400 psi,
Easley says it can endure as much as 900
psi for short periods, and tolerate temperatures to 200 degrees F long enough
to accommodate hot oiling. "The pipe
was engineered to have abrasion and impact resistance, chemical tolerance, and
the toughness to endure pressure and
temperature spikes so operators have the
peace of mind that comes with knowing
it can deal with the unexpected," he concludes.
❒

SEPTEMBER 2015 119



American Oil and Gas Reporter - September 2015

Table of Contents for the Digital Edition of American Oil and Gas Reporter - September 2015

Contents
American Oil and Gas Reporter - September 2015 - Cover1
American Oil and Gas Reporter - September 2015 - Cover2
American Oil and Gas Reporter - September 2015 - 3
American Oil and Gas Reporter - September 2015 - 4
American Oil and Gas Reporter - September 2015 - Contents
American Oil and Gas Reporter - September 2015 - 6
American Oil and Gas Reporter - September 2015 - 7
American Oil and Gas Reporter - September 2015 - 8
American Oil and Gas Reporter - September 2015 - 9
American Oil and Gas Reporter - September 2015 - 10
American Oil and Gas Reporter - September 2015 - 11
American Oil and Gas Reporter - September 2015 - 12
American Oil and Gas Reporter - September 2015 - 13
American Oil and Gas Reporter - September 2015 - 14
American Oil and Gas Reporter - September 2015 - 15
American Oil and Gas Reporter - September 2015 - 16
American Oil and Gas Reporter - September 2015 - 17
American Oil and Gas Reporter - September 2015 - 18
American Oil and Gas Reporter - September 2015 - 19
American Oil and Gas Reporter - September 2015 - 20
American Oil and Gas Reporter - September 2015 - 21
American Oil and Gas Reporter - September 2015 - 22
American Oil and Gas Reporter - September 2015 - 23
American Oil and Gas Reporter - September 2015 - 24
American Oil and Gas Reporter - September 2015 - 25
American Oil and Gas Reporter - September 2015 - 26
American Oil and Gas Reporter - September 2015 - 27
American Oil and Gas Reporter - September 2015 - 28
American Oil and Gas Reporter - September 2015 - 29
American Oil and Gas Reporter - September 2015 - 30
American Oil and Gas Reporter - September 2015 - 31
American Oil and Gas Reporter - September 2015 - 32
American Oil and Gas Reporter - September 2015 - 33
American Oil and Gas Reporter - September 2015 - 34
American Oil and Gas Reporter - September 2015 - 35
American Oil and Gas Reporter - September 2015 - 36
American Oil and Gas Reporter - September 2015 - 37
American Oil and Gas Reporter - September 2015 - 38
American Oil and Gas Reporter - September 2015 - 39
American Oil and Gas Reporter - September 2015 - 40
American Oil and Gas Reporter - September 2015 - 41
American Oil and Gas Reporter - September 2015 - 42
American Oil and Gas Reporter - September 2015 - 43
American Oil and Gas Reporter - September 2015 - 44
American Oil and Gas Reporter - September 2015 - 45
American Oil and Gas Reporter - September 2015 - 46
American Oil and Gas Reporter - September 2015 - 47
American Oil and Gas Reporter - September 2015 - 48
American Oil and Gas Reporter - September 2015 - 49
American Oil and Gas Reporter - September 2015 - 50
American Oil and Gas Reporter - September 2015 - 51
American Oil and Gas Reporter - September 2015 - 52
American Oil and Gas Reporter - September 2015 - 53
American Oil and Gas Reporter - September 2015 - 54
American Oil and Gas Reporter - September 2015 - 55
American Oil and Gas Reporter - September 2015 - 56
American Oil and Gas Reporter - September 2015 - 57
American Oil and Gas Reporter - September 2015 - 58
American Oil and Gas Reporter - September 2015 - 59
American Oil and Gas Reporter - September 2015 - 60
American Oil and Gas Reporter - September 2015 - 61
American Oil and Gas Reporter - September 2015 - 62
American Oil and Gas Reporter - September 2015 - 63
American Oil and Gas Reporter - September 2015 - 64
American Oil and Gas Reporter - September 2015 - 65
American Oil and Gas Reporter - September 2015 - 66
American Oil and Gas Reporter - September 2015 - 67
American Oil and Gas Reporter - September 2015 - 68
American Oil and Gas Reporter - September 2015 - 69
American Oil and Gas Reporter - September 2015 - 70
American Oil and Gas Reporter - September 2015 - 71
American Oil and Gas Reporter - September 2015 - 72
American Oil and Gas Reporter - September 2015 - 73
American Oil and Gas Reporter - September 2015 - 74
American Oil and Gas Reporter - September 2015 - 75
American Oil and Gas Reporter - September 2015 - 76
American Oil and Gas Reporter - September 2015 - 77
American Oil and Gas Reporter - September 2015 - 78
American Oil and Gas Reporter - September 2015 - 79
American Oil and Gas Reporter - September 2015 - 80
American Oil and Gas Reporter - September 2015 - 81
American Oil and Gas Reporter - September 2015 - 82
American Oil and Gas Reporter - September 2015 - 83
American Oil and Gas Reporter - September 2015 - 84
American Oil and Gas Reporter - September 2015 - 85
American Oil and Gas Reporter - September 2015 - 86
American Oil and Gas Reporter - September 2015 - 87
American Oil and Gas Reporter - September 2015 - 88
American Oil and Gas Reporter - September 2015 - 89
American Oil and Gas Reporter - September 2015 - 90
American Oil and Gas Reporter - September 2015 - 91
American Oil and Gas Reporter - September 2015 - 92
American Oil and Gas Reporter - September 2015 - 93
American Oil and Gas Reporter - September 2015 - 94
American Oil and Gas Reporter - September 2015 - 95
American Oil and Gas Reporter - September 2015 - 96
American Oil and Gas Reporter - September 2015 - 97
American Oil and Gas Reporter - September 2015 - 98
American Oil and Gas Reporter - September 2015 - 99
American Oil and Gas Reporter - September 2015 - 100
American Oil and Gas Reporter - September 2015 - 101
American Oil and Gas Reporter - September 2015 - 102
American Oil and Gas Reporter - September 2015 - 103
American Oil and Gas Reporter - September 2015 - 104
American Oil and Gas Reporter - September 2015 - 105
American Oil and Gas Reporter - September 2015 - 106
American Oil and Gas Reporter - September 2015 - 107
American Oil and Gas Reporter - September 2015 - 108
American Oil and Gas Reporter - September 2015 - 109
American Oil and Gas Reporter - September 2015 - 110
American Oil and Gas Reporter - September 2015 - 111
American Oil and Gas Reporter - September 2015 - 112
American Oil and Gas Reporter - September 2015 - 113
American Oil and Gas Reporter - September 2015 - 114
American Oil and Gas Reporter - September 2015 - 115
American Oil and Gas Reporter - September 2015 - 116
American Oil and Gas Reporter - September 2015 - 117
American Oil and Gas Reporter - September 2015 - 118
American Oil and Gas Reporter - September 2015 - 119
American Oil and Gas Reporter - September 2015 - 120
American Oil and Gas Reporter - September 2015 - 121
American Oil and Gas Reporter - September 2015 - 122
American Oil and Gas Reporter - September 2015 - 123
American Oil and Gas Reporter - September 2015 - 124
American Oil and Gas Reporter - September 2015 - 125
American Oil and Gas Reporter - September 2015 - 126
American Oil and Gas Reporter - September 2015 - 127
American Oil and Gas Reporter - September 2015 - 128
American Oil and Gas Reporter - September 2015 - 129
American Oil and Gas Reporter - September 2015 - 130
American Oil and Gas Reporter - September 2015 - 131
American Oil and Gas Reporter - September 2015 - 132
American Oil and Gas Reporter - September 2015 - 133
American Oil and Gas Reporter - September 2015 - 134
American Oil and Gas Reporter - September 2015 - 135
American Oil and Gas Reporter - September 2015 - 136
American Oil and Gas Reporter - September 2015 - 137
American Oil and Gas Reporter - September 2015 - 138
American Oil and Gas Reporter - September 2015 - 139
American Oil and Gas Reporter - September 2015 - 140
American Oil and Gas Reporter - September 2015 - 141
American Oil and Gas Reporter - September 2015 - 142
American Oil and Gas Reporter - September 2015 - 143
American Oil and Gas Reporter - September 2015 - 144
American Oil and Gas Reporter - September 2015 - 145
American Oil and Gas Reporter - September 2015 - 146
American Oil and Gas Reporter - September 2015 - 147
American Oil and Gas Reporter - September 2015 - 148
American Oil and Gas Reporter - September 2015 - 149
American Oil and Gas Reporter - September 2015 - 150
American Oil and Gas Reporter - September 2015 - 151
American Oil and Gas Reporter - September 2015 - 152
American Oil and Gas Reporter - September 2015 - 153
American Oil and Gas Reporter - September 2015 - 154
American Oil and Gas Reporter - September 2015 - 155
American Oil and Gas Reporter - September 2015 - 156
American Oil and Gas Reporter - September 2015 - 157
American Oil and Gas Reporter - September 2015 - 158
American Oil and Gas Reporter - September 2015 - 159
American Oil and Gas Reporter - September 2015 - 160
American Oil and Gas Reporter - September 2015 - 161
American Oil and Gas Reporter - September 2015 - 162
American Oil and Gas Reporter - September 2015 - 163
American Oil and Gas Reporter - September 2015 - 164
American Oil and Gas Reporter - September 2015 - 165
American Oil and Gas Reporter - September 2015 - 166
American Oil and Gas Reporter - September 2015 - 167
American Oil and Gas Reporter - September 2015 - 168
American Oil and Gas Reporter - September 2015 - 169
American Oil and Gas Reporter - September 2015 - 170
American Oil and Gas Reporter - September 2015 - 171
American Oil and Gas Reporter - September 2015 - 172
American Oil and Gas Reporter - September 2015 - 173
American Oil and Gas Reporter - September 2015 - 174
American Oil and Gas Reporter - September 2015 - 175
American Oil and Gas Reporter - September 2015 - 176
American Oil and Gas Reporter - September 2015 - 177
American Oil and Gas Reporter - September 2015 - 178
American Oil and Gas Reporter - September 2015 - Cover3
American Oil and Gas Reporter - September 2015 - Cover4
http://staging.nxtbook.com/nxtbooks/aogr/201702/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201701/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201612/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201611/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201610/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/pbios2016_programguide/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201609/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201608/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201607/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201606/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201605/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201604/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201603/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201602/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201601/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201512/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201511/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201510/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201509/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201508/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201507/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201506/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201505/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201504/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201503/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201502/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201501/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201412/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201411/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201410/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201409/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/pbios2014_programguide/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201408/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201407/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201406/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201405/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201404/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201403/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201402/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201401/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201312/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201311/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201310/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201309/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201308/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201307/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201306/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201305/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201304/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201303/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201302/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201301/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201212/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201211/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201210/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201209/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/2012_pbios/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201208/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201207/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201206/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201205/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201204/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201203/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201202/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201201/stage.php
http://staging.nxtbook.com/nxtbooks/demo/aogr_clone/stage.php
http://staging.nxtbook.com/nxtbooks/aogr/201112/stage.php
https://www.nxtbookmedia.com